phonic xp 600 1000

POWER AMPLIFIER
XP 600/1000
POWER AMPLIFIER
XP600/1000
600/1000
PANEL LAYOUT.............................................................3
SYSTEM BLOCK DIAGRAM...........................................5
PCB
POWER AMPLIFIER PCB...............................................6
POWER SUPPLY PCB.....................................................7
MODE & POWER ON DISPLAY PCB................................8
INPUT PCB.....................................................................9
SPEAKON OUTPUT PCB...............................................11
LEVEL & STATUS DISPLAY.............................................12
SCHEMATICS
POWER AMPLIFIER SCHEMATIC..................................14
POWER SUPPLY SCHEMATIC.......................................16
INPUT & CONTROL DISPLAY SCHEMATICS ....................17
PART LIST
POWER AMPLIFIER PCB-PART LIST................................18
POWER SUPPLY PCB-PART LIST......................................22
MISCELLAN E OUS ITEMS ..................................................26
POWER REQUIREME N T CLASSIFICATION .......................29
DIME N SIONS .....................................................................33
Phonic reserves the right to improve or alter any information supplied within this
document without prior notice.
V2.1
09/05/02
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 2
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
1
-14
-6
-20
-40
CLIP/LIMIT
CLIP
PROTECT
-10
-6
-6
0
0
KNOB:540-20390-120-0
POT:023-50230-040-0
-32
-32
-40
-20
-10
PROTECT
CLIP
CLIP/LIMIT
PROTECT
CLIP
CLIP/LIMIT
CLIP/LIMIT
100-00010-030-0
PROTECT
100-00040-020-0
2
LED
100-00050-020-0
00
-6-6
-14
-14
-16
-16
-14
LED
100-00050-020-0
-32
-32
-16
-16
0
0
-40
-20
-16
-32
-10
POWER
POWER
-40
-6
PROTECT
-14
-20
-16
-10
-32
POWER SW
210-03101-070-0
LED:100-00110-000-0 RED
LED:100-00150-020-0 GRN
LED:100-00240-020-0 YLW
CLIP/LIMIT
CLIP
CLIP/LIMIT
100-00010-030-0
PROTECT
100-00040-020-0
XP 600/1000 (FRONT)
PANEL LAYOUT
Page 3
4
PHONIC CORPORATION
LIS
TED
R
US C
LI
R
S TED
119301
US
XP 600/1000 SERVICE MANUAL
CAUTION
CH 1
SPEAKON JACK
211-03400-021-0
AVIS: RISQUE DE CHOC ELECTRIQUE
NE PAS OUVRIR
CH 2
BRIDGE
MONO
OUTPUT
BINDING POST
211-17000-410-0
GND
610-10002-130-0
POWER CORD
370-08810-702-0
CERTIFIED TO CSA STD. C22.2 NO.1
CONFORMS TO ANSI/UL STD-813
C
~ 240 VAC 50Hz
~ 230 VAC 50Hz
~ 120 VAC 60Hz
~ 100 VAC 60Hz
TO REDUCE THE RISK
OF FIRE OR ELECTRIC
SHOCK DO NOT EXPOSE
THIS EQUIPMENT
TO
RAIN
OR MOISTURE.
WARNING!
XP 600/1000 (REAR)
PIN OUT
OFF
LIMITER
ON
1 / 4"
TIP
RNG
SLV
MODE
XLR
PIN 2
PIN 3
PIN 1
INPUT
HPF
XLR JACK
211-03300-160-0
STEREO
BRIDGE
50Hz
PARALLEL
30Hz
OFF
OFF AMPLIFIER
CAUTION : TURN
BEFORE ADJUSTING!
CH 1
SLD SW:
210-60001-000-0
FLOATING
GROUNDING
CH 2
XLR JACK
211-03300-160-0
1/4" JACK
211-01602-560-0
3
1
FAN NET
528-00000-000-0
FAN
247-00000-201-0
2
PANEL LAYOUT
Page 4
SYSTEM BLOCK DIAGRAM
SYSTEM BLOCK DIAGRAM
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 5
POWER AMPLIFIER PCB
POWER AMPLIFIER PCB
C205
R202
+15V
LIM
SIGN
PROT
PGND
-
-15V
+
IC201
C206
R306
R308
C302
FAN
C314
R307
C201
C202
Q201
C208
Q204
A
A
C211
PIII1000/600_AMP.PCB
290-34610-100-0 REV A
R201
CN10
CN14
C207
R204
C203
C
E
B
C
C
Q202
Q205
C
E
E
R305
R304
R303
R207
C
C212
R301
C214
Q207
C213
R225
B
C
Q301
E
E
R219
R220
R221
ZD203
B
R229
D206
D205
ZD204
R226
C215
Q208
C216
R216
R217
C
B
B
B
B
E
B
C
E
C
Q203
C209
C210
R281
B
C
B
JP16
B
R227
R215
R240
B
NTC4
C231
B
R223
E
R218
R224
SVR201
C217
E
Q206
R247
R228
R278
R234
R264
D207
D210
R248
R279
Q214
B
C
B
C
R276
R277
R266
Q233
R275
E
A
BA
C222
Q215
E
E
A
C
A
B
C
CA
Q222
E
B
EA
R265
Q232
C229
C228
R280
C220
D219
R267
R249
R235
R241
C221
R254
Q209
B
C301
R214
R213
R212
D203
D204
ZD201
ZD202
R203
R205
R206
R208
D201
B
B
R209
R210
D202
R211
R222
B
C204
R302
C313
C
B
Q302
E
E
D220
R268
B
A
EA
R274
D209
ZD207
C
Q216
D215
A
A
A
A
ZD206
A
C A
Q223
D214
R273
E
A
BA
+
R242
R236
R250
C226
C225
C230
C223
C219
+
R255
C218
R269
B
EA
R270
A
C
Q221
E
C
A
R271
E
D
D
A
D211
BA
R243
D
D216
C227
C224
D
R256
D222
G
A
9
A
S
G
R230
Q211
R231
Q316
E
C
B
R336
R337
Q315
E
C312
B
E
C
E
E
Q309
C311
CN6
AGND
P_IN
OP_O
AGND
+15V
-15V
Q307
A
D302
R328
R331
C
R324 R339
R323
R322
C307
B
C
C
E
B
C
A
B
C308
R326
R320
R329
D303
R325
B
Q314
TMP1
R333
R338
R332
ZD302
C
A
B
L301
E
C304
C
A
E
B
B
C305
Q311
R327
CN15
S
Q312
ZD301
1
R321
D304
R319
R334 C316
D306
R335
B
A
D
C309
E
C310
E
G
C
A
R341
R340
R342
C315
Q308
B
C306
G
R330
Q310
PHONIC CORPORATION
Q306
E
2
C
5
RA2
A
R318
R317
R316
R261
D
3
B
A
S
Q229
C
A
D
A
D
D305
4
6
B
Q210
8
D
7
+100V
6
PGND
5
-100V
D
-65V
4
+65V
3
PGND
2
D
VAC
A
V+
SPK-O
D
Q228
D221
A
S
CN9
1
R260
Q313
Q217
B
CA
Q224
ZD205
D208
R272
XP 600/1000 SERVICE MANUAL
Page 6
POWER SUPPLY PCB
POWER SUPPLY PCB
PIII1000/600
POWER_C.PCB REV_A
290-34610-203-0
R137
C12
SW1
CAUTION:
SW4
SW3
TO REDUCE THE RISK OF FIRE
R146
SW2
BEPLACE ONLY WITH SAME TYPE FUSE
ATTENTION:
C119
C108
CN2
/\
DE RECHANGE DE MENE TYPE
D3
CN1
JP4
C11
D2
I
G
JP8
O
G
IC1
I
O
LM7815
C4
+
C7
IC2
C8
LM7915
RA1
JP5
R116
R143
R144
UTILISER UN FUSIBLE
R3
AC1
R1
TR1_115
TR2_115
NTC1
C
C
B
NTC3
-
+
NTC2
+
+
R7
Q2
R6
E
R4
Q1 E
C2
+
SPK GND L
SPK GND R
P7
TR1_115
TR2_0
C9
P10
P9
+
-
P8
B
+
D1 R2
P3
TR1_0
P6
+
BD2
BD1
R5
C5
F2
C10
C1
TR2_0
P5
~
+
T1
T2A 250V
JP9A
8.V+
7.VAC
6.PGND
5.-50V
4.+50V
2.-80V
3.PGND
1.+80V
-
WIT
BWN
WIT
BLU
YLW
BLK
BLU
YLW
PHONIC CORPORATION
~
T2A 250V
JP9B
P/SW
BD3
F1
XP 600/1000 SERVICE MANUAL
P2
Page 7
MODE & POWER ON DISPLAY PCB
CN8
MODE & POWER ON DISPLAY PCB
LED11
LED8
LED9
LED10
R145
R145B
LED1
LED2
LED3
LED4
LED5
LED6
LED7
R145A
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 8
PHONIC CORPORATION
D102
JP7
C122
JK3
R153
1
2
+
LED102
CDS2
JK3A
4
3
290-34610-301-0
PIII1K INPUT_D.PCB
REV A
JP2
C145
JP1
CDS1
1
2
+
JK2
LED101
JK2A
C111
D101
~
-
+
~
JP6
4
3
INPUT PCB (FRONT )
INPUT PCB (FRONT )
C109
C120
~
-
+
~
XP 600/1000 SERVICE MANUAL
Page 9
4
INPUT PCB (REAR)
INPUT PCB (REAR )
R101
R104
R107
C102
C103
C101
R106
R105
R110
R102
R119
R108
C105
R121
R109
R103
R120
C104
IC2
R115
R114
C106
C107
R112
R111
R113
C110
IC3
IC3
R117
R118
R136
R135
C117
R133
C118
R132
R134
C121
R138
R139
R124
R128
C113
R125
R140
R153
C146
IC4
R131 R122
R123
C112
R127
R126
R142
C114
R141
C115
R129
C116
R130
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 10
SPEAKON OUTPUT PCB
JK4
2-
2+
1+
1-
JK5
A3
A4
2-
2+
1+
A1
A2
1-
SPEAKON OUTPUT PCB
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 11
LEVEL & STATUS DISPLAY PCB ( FRONT)
Q305B
B
C
C
LED301B
E
E
Q304B
B
C
Q303B
B
LED305B
E
R314B
R312B
R313B
LEVEL & STATUS DISPLAY PCB ( FRONT)
LED304B
PCB_E
LED303B
VR2
LED302B
JP10B
CN5
CN4
PHONIC CORPORATION
B
C
VR1
PCB_F
Q305A
E
B
C
Q304A
E
B
C
Q303A
R312A
R313A
E
R314A
JP10A
LED301A
LED305A
LED302A
LED303A
LED304A
XP 600/1000 SERVICE MANUAL
Page 12
LEVEL & STATUS DISPLAY PCB( REAR)
PHONIC CORPORATION
R345A
R309A
R309B
R345B
R344B
R311B
R310B
R343B
R343A
R311A
R310A
R344A
LEVEL & STATUS DISPLAY PCB( REAR)
XP 600/1000 SERVICE MANUAL
Page 13
POWER AMPLIFIER SCHEMATIC (2-1)
POWER AMPLIFIER SCHEMATIC ( 2-1)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page
Page 14
4
POWER AMPLIFIER SCHEMATIC (2-2)
POWER AMPLIFIER SCHEMATIC (2-2)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 15
POWER SUPPLY SCHEMATIC
POWER SUPPLY SCHEMATIC
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 16
INPUT & CONTROL DISPLAY SCHEMATICS
INPUT
MODE & POWER ON DISPLAY
INPUT & CONTROL DISPLAY SCHEMATICS
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 17
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
210-10090-001-0
TMP/SW US-602SXRFQC
212-10023-440-0
2P WAFER/P 100MM
526-20551-010-0
HEAT SINK XP600/1000
552-20063-400-0
TRAN. FIXED XP600/1000
66*26*1.9MM
552-20064-400-0
FET FIXED XP600/1000
37*20*1.9MM
290-34610-101-0
PCB XP600/1000 A+B AMP
C201.203.210
030-10656-0A0-0
E/C 10MF M 50V 5*11 T
C202.204
042-47325-050-0
C/C2 0.047MF K 50V 5 T
C205
032-10636-0A0-0
NP E/C 10MF M 25V 6.3*11 T
C206
042-33024-050-0
C/C2
33PF J 50V 5 T
C207.209.225
042-10225-050-0
C/C2
0.001MF K 50V 5 T
C212.217
030-47695-000-0
E/C 47MF K 160V P
C213.216
042-47164-050-0
C/C2 470PF J 350V 5 T
C214.215
042-10345-160-6
C/C2 0.01UF K 100V T
C218
042-56224-050-0
C/C2 0.0056MF J 50V T
C219.226.308
030-10728-0A0-0
E/C
C220.221
042-10124-050-0
C/C2
100PF J 50V T
C222
042-03020-000-0
C/C2
3PF C 50V 5
C223.224.227.230
042-104A8-000-0
C/C2
0.1MF Z 250V 5
C228
042-391A4-050-0
C/C2 390PF J 250V 5 T
C229
042-201A5-000-0
C/C2 200PF K 250V
C231.315.316
042-10426-050-0
C/C2
C301
030-10638-0A0-0
E/C
C302
032-22586-0A0-0
NP E/C 2.2MF M 100V 6*11 T
C304.305
046-10414-060-0
M/C 0.1MF J 100V 5 T
C306
030-22728-0A0-0
E/C 220MF Z 16V 8*11 T
C307
042-47124-050-0
C/C2
C309
030-10558-0A0-0
E/C
1MF Z 50V 5*11 T
C310.311.312
030-22638-0A0-0
E/C
22MF Z 25V 5*11 T
C313.314
030-47638-0A0-0
E/C 47MF Z 25V 6.3*11 T
CN14
211-10021-150-0
2P WAFER/S 5267 A2505 WV
100MF Z 16V 6*11 T
0.1MF M 50V 5 T
10MF Z 25V 5*11 T
470PF J 50V 5 T
P=2.5MM 180GEGREE
CN15
211-10021-161-0
2P WAFER/S TJC3-2A
P=2.5MM 180GEGREE
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 4
18
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
CN6.10
211-10061-171-0
6P WAFER/S TJC3-6A
P=2.5mm
CN9
211-10093-000-0
9P WAFER/S 3.96MM
D201.202.203.206.303.3
090-02000-020-0
DIODE 1N4148 T
D204.205.302.305.306
090-00007-020-0
DIODE IN4004 SILTEK T
D207-210.219.220
090-02004-000-0
DIODE 1N4935 T
D211.216
090-02007-000-0
DIODE FR602
D214.215.221.222
090-00016-000-0
DIODE 1N5404
FIX IC1.2
313-00000-000-0
TRANSISTOR WASHER
04
TO-220
HEAT
610-00300-501-0
PLA. WAS.
D3.0*D7.0*0.5 NI
IC201
160-00021-900-0
IC NJM5534D JRC
L301
075-10082-100-0
INDUCTANCE
NTC4
011-10020-001-0
THERMISTER NSA05C3 10-301
Q201
120-00001-400-0
TRAN.
Q202.316
121-00006-100-0
TRAN MJE350 MOTOROLA
Q203.301
120-00008-800-0
TRAN MJE802 MOTOROLA
Q204.214.232.233
121-00000-300-0
TRAN.
Q205.221
120-00005-000-0
TRAN MJE340 MOTOROLA
Q206
121-00007-200-0
TRAN 2SA1837-M TOSHIBA
Q207
121-00007-500-0
TRAN. BC556B PHILIPS
SINK&TRANSISTOR
1UH K M
2N5551 MOTOROLA
2N5401 MOTOROLA
(BC560)
Q208
120-00009-700-0
TRAN. BC546B PHILIPS
(BC550)
Q209
120-00009-500-0
TRAN 2SC4793-M TOSHIBA
Q210.228
122-00002-500-0
MOSFET IRFP250
Q210.228
313-00010-000-0
WASHER
Q215.216.217
120-00008-600-0
TRAN 2SC5200-O
TO-3P
TOSHIBA(XP1000)
Q215.217
120-00008-600-0
TRAN 2SC5200-O
TOSHIBA(XP600)
Q222.224
121-00006-000-0
TRAN 2SA1943-O TOSHIBA
Q302.306.308.309.310.3
120-00000-800-0
TRAN.
12.314.315
Q307.311.313
PHONIC CORPORATION
2SC1815 GR
TOSHIBA
121-00000-200-0
TRAN.
2SA1015 GR
XP 600/1000 SERVICE MANUAL
Page 19
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
R201
006-49912-420-0
MF RES.
R202
006-51022-420-0
MF RES. 51K F 0.25W T
R203.204.212.216.217.2
006-10012-420-0
MF RES. 1K F 0.25W M
R205.206.317.318
006-39012-420-0
MF RES. 3K9 F 0.25W M
R207.234.236.254.256
006-10072-420-0
MF RES. 10F 0.25W M
R208.211.265.267.276.32
006-10022-420-0
MF RES.
R209.210.303.333
006-68022-420-0
MF RES. 68K F 0.25W M
R213.214.220.221.305.3
006-10002-420-0
MF RES. 100 F 0.25W M
R215.218
006-47083-420-0
MF RES. 4.7 F 0.5W M
R222.229.307.323.335
006-22012-420-0
MF RES. 2K2 F 0.25W M
R223
006-62012-440-0
MF RES.
4K99 F 0.25W M
19.279.306
10K F 0.25W M
4.331.332.339
26.338
6K2 F 0.25W T
(XP600)
R223.228
006-27012-400-0
MF RES. 2K7 J 0.25W T
R224.227
006-30012-440-0
MF RES. 3K F 0.25W T
R225.226
006-20022-420-0
MF RES.
R228
006-56012-400-0
MFRES. 5K6 F 0.25W T(XP600)
R230.264.260.277.278
006-51072-420-0
MF RES. 51F 0.25W M
R240.247
006-10003-420-0
MF RES. 100F 0.5W M
R241.243.248.250
003-22093-602-0
CEMENT RES. 0.22 J 5W
R266
006-33002-420-0
MF RES.
R268.342
006-33022-420-0
MF RES. 33K F 0.25W M
R269.280
006-15023-420-0
MF RES. 15K F 0.5W M
R270
006-82012-440-0
MF RES.
8K2 F 0.25W T
R271
006-47012-420-0
MF RES.
4K7 F 0.25W M
R272
006-27023-420-0
MF RES.27K F 0.5W M
R273
006-30022-420-0
MF RES. 30K F 0.25W M
R274
006-18022-420-0
MF RES. 18K F 0.25W M
R275
006-27032-420-0
MF RES. 270K F 0.25W M
R281
003-10071-602-0
CEMENT RES.
R301
006-75002-420-0
MF RES.
750 F 0.25W M
R304
006-27022-420-0
MF RES.
27K F 0.25W M
R308.327.334
006-10032-420-0
MF RES. 100K F 0.25W M
R316
003-22071-601-0
CEMENT RES. 22 J 2W
R319
006-68012-420-0
MF RES.
PHONIC CORPORATION
20K F 0.25W M
330 F 0.25W M
10 J 2W P
6K8 F 0.25W M
XP 600/1000 SERVICE MANUAL
Page 4
20
POWER AMPLIIFIER PCB-PART LIST
POWER AMPLIIFIER PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
R320.321.322
006-22032-420-0
MF RES. 220K F 0.25W M
R325.336.337.340
006-22022-420-0
MF RES. 22K F 0.25W M
R328
006-33012-410-0
MF RES. 3K3 F 0.25W P
R329
006-56022-420-0
MF RES. 56K F 0.25W M
R330
006-12022-420-0
MF RES. 12K F 0.25W M
R341
006-15012-420-0
MF RES.
RA2
076-02421-000-0
RELAY JC2AF-DC24V
1K5 F 0.25W M
MATSUSHITA
SVR201
020-47171-000-6
T/VR 470 0.5W 3U 10-1-25
THERMAL SW*2
590-43008-100-0
M/E PAN SCR.
M3.0*8 NI
THERMAL SW*5
590-43012-100-0
M/E PAN SCR.
M3.0*12 NI
TRANSISTOR*6
590-43014-100-0
M/E PAN SCR M3.0*14 NI
TRERMAL RES.*1
610-60300-501-0
PAN SPR. WAS D3.0*D7*0.5 NI
ZD201.202
090-01752-010-0
ZEN/DIODE
7V5 K 0.5W
FAIRCH
ZD203.204.205.301.302
090-01682-000-0
ZEN/DIODE 6.8V J0.5W
UNIZO(XP1000)
ZD203.204.301
090-01682-000-0
ZEN/DIODE 6.8V J0.5W
UNIZO(XP600)
ZD205
382-20010-010-0
TINNER WIRE 10MM D0.6
(XP600)
ZD206
090-01103-010-0
Z/DIODE
10V K 0.5W FAIRC
ZD207
090-01153-010-0
Z/DIODE
15V K 0.5W
UNIZON
ZD302
PHONIC CORPORATION
090-01472-000-0
Z/DIODE 4.7V J 0.5W FAIRC
XP 600/1000 SERVICE MANUAL
Page 21
16
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
281-00000-010-0
FUSE CLIP
FH-1208
(XP1000)
313-00000-060-0
RUBBER WASHER TO-2203
314-00000-050-0
BUSHES 602S(V.0)
180GEGREE
526-20040-010-0
HEAT.SINK POD1860 20*18
590-53010-100-0
M/E SET SCR.
600-00302-010-0
HEX. NUT
610-60300-700-0
PAN SPR WAS.
M3.0*10 NI
M3.0*2.0 NI
D3.0*6.0*0.7ZN
290-34610-202-0
PCB XP600/1000 C+G
PWR+LED
615-20104-620-0
LED HOLDER 3LED-3
290-34610-301-0
XP600/1000 D+E+F PCB
A1
212-10010-690-0
1P WAFER/P 80MM BWN
A2
212-10010-680-0
1P WAFER/P 80MM
UL1015#14 BLK
A3
212-10010-720-0
1P WAFER/P 80MM
UL1015#14 RED
A4
212-10010-730-0
1P WAFER/P 80MM
UL1015#14 ORANGE
BD1.2
090-10016-000-0
B/DIODE KBPC5006
BD3
090-10000-000-0
B/DIODE
C1
058-68325-100-0
MEX-683K 0.068MF/250V
PB154
18*13.5 P=15
C101.102.112.113
039-22024-220-0
CHIP C/C 22PF J 50V 0603
C103.104.105.114.115.11
039-33435-220-0
CHIP. C/C 0.33MF 10V K 0603
C106.107.117.118
039-10405-220-0
CHIP C/C 0.1UF K 16V 0603
C108.119
030-22628-0A0-0
E/C
22MF Z 16V 5*11 T
C109.120
030-22628-000-0
E/C
22MF Z 16V 5*11 P
C11.12
030-10656-0A0-0
E/C 10MF M 50V 5*11 T
C110.121
039-33024-220-0
CHIP C/C 33PF J 50V 0603
C111.122
030-47628-0A0-0
E/C
C145
030-10484-000-0
E/C 0.1MF J 100V 5
6
PHONIC CORPORATION
47MF Z 16V 5*11 T
XP 600/1000 SERVICE MANUAL
Page 4
22
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
C146
039-10324-220-0
CHIP C/C 0.01MF J 50V 0603
C2
030-47558-0A0-0
E/C
4.7MF Z 50V 5*11 T
(XP1000)
C4.5
030-47878-000-0
E/C 4700MF Z 80V 31*35 P
(XP600)
C4.5
030-47888-030-0
E/C 4700MF Z 100V 35*52 P
(XP1000)
C7.8
030-33866-030-0
E/C 3300UF M 63V 25*30 P
(XP600)
C7.8
030-33876-000-0
E/C 3300MF M 80V 30*31 P
(XP1000)
C9.10
030-22848-002-0
E/C 2200MF Z 35V 16*27 P
CDS1.2
010-00001-010-0
CDS
P873-G35-552
HAMAMATSU
CN1
211-09142-000-0
14P B.E./S 180GEGREE
CN2
211-09202-000-0
20P B.E./S 180GEGREE
CN4.5
211-10031-170-0
3P WAFER/S 2532-03
(PITCH:2.5MM)
CN8
211-10041-140-0
4P WAFER/S 2532-04
D101.102
090-10000-000-0
B/DIODE
D2.3
090-00007-020-0
DIODE IN4004 SILTEK T
FUSE1*2.FUSE2*2
281-00000-020-0
FUSE CLIP
PB154
FH-1206
(XP1000)
IC1
160-00005-909-0
IC 7815
IC1-4
160-00021-300-0
IC NJM2068 SMD JRC
IC2
160-00002-909-0
IC 7915
JK2A.3A
211-01602-560-0
6D4/J YLJ-6405-300
(NUT&WASHER)
JK2A.3A
211-03300-160-0
XLR/J SKCA229-1K3F2
JK4.5
211-03400-021-0
SPEAKON/J SVP563S-CH
JP1
212-11214-000-0
IC/P 120MM
JP10A.10B
212-10061-360-0
6P WAFER/P 120MM
JP2
212-11220-000-0
IC/P 120MM XP2000/3000
PH=2.54MM
JP4
212-10032-490-0
3P WAFER/P 440MM
JP5
212-10032-480-0
3P WAFER/P 520MM
(PITCH=2.5MM)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 23
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
JP6
212-10061-370-0
6P WAFER/P 150MM
JP7
212-10061-380-0
6P WAFER/P 300MM
JP8
212-10041-220-0
4P WAFER/P 500MM
JP9A
212-10090-440-0
9P WAFER/P 250MM
UL1015#16 PITCH=3.96MM
JP9B
212-10090-460-0
9P WAFER/P 140MM
LED1
100-00150-020-0
LED
LED1.2
615-10054-620-0
LED BOSS
LED101.102.301A.301B
100-00010-030-0
LED BL-B5141 RED
LED2
100-00110-000-0
LED BL-R5132N RED
LED302A.302B.303A.303
100-00050-000-0
LED BL-B2141 GRN
LED305A.305B
100-00040-000-0
LED
LED3-11
100-00240-020-0
LED 5*5mm YLW
NTC1.2.3
012-400B0-000-0
NTC THERMISTORS
LG5120 GRN
L=6MM(XP1000)
B.304A.304B
204YD YLW
N15SP004(XP1000)
NTC1.2.3
382-20010-010-0
TINNER WIRE 10MM D0.6
(XP600)
P2.3.5-10
315-00012-000-0
LUG PIN JP-15
Q303A.303B.304A.304B.
120-00000-800-0
TRAN.
305A.305B
R1
2SC1815 GR
TOSHIBA
006-47032-420-0
MF RES. 470K F 0.25W M
(XP1000)
R101.103.122.124.311A.
008-01042-600-0
CHIP RES. 100K J 0603
R102.112.123.133
008-02232-600-0
CHIP RES. 22K J 0603
R104-107.125-128
008-01532-600-0
CHIP RES. 15K J 0603
R108.129
008-01232-600-0
CHIP RES. 12K J 0603
R109.130
008-08232-600-0
CHIP RES. 82K J 0603
R110.131
008-04322-600-0
CHIP RES. 4.3K J 0603
R111.132
008-04732-600-0
CHIP RES. 47K J 0603
R113.114.115.134.135.13
008-02212-600-0
CHIP RES. 220 J 0603
R116.137
006-33011-400-0
MF RES. 3K3 F 0.125W T
R117.138.309A.309B
008-01032-600-0
CHIP RES. 10K J 0603
R118.139
008-04332-600-0
CHIP RES. 43KJ 0603
R119.140
008-03322-600-0
CHIP RES. 3.3K J 0603
311B
6
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 24
POWER SUPPLY PCB-PART LIST
POWER SUPPLY PCB-PART LIST
Re f.
Phonic Part No.
Desc ription
R120.141
008-01512-600-0
CHIP RES. 150 J 0603
R121.142
008-03922-600-0
CHIP RES. 3.9K J 0603
R143.144
006-10012-420-0
MF RES. 1K F 0.25W M
R145.145A.145B
006-56003-420-0
MF RES. 560 F 0.5W M
R146
006-33022-420-0
MF RES. 33K F 0.25W M
R153
006-10073-420-0
MF RES. 10F 0.5W M
R2
006-10022-420-0
MF RES.
10K F 0.25W M
(XP1000)
R3
005-10127-100-0
MOF RES. 100OHM
2W P
(XP1000)
R310A.310B
008-02032-600-0
CHIP RES. 20K J 0603
R312A.312B.313A.313B.
006-10012-420-0
MF RES. 1K F 0.25W M
008-07522-600-0
CHIP RES. 7.5K J 0603
314A.314B
R343A.343B
(XP1000)
R343A.343B
008-08222-600-0
CHIP RES. 8.2K J 0603
(XP600)
R344A.344B
008-04722-600-0
CHIP RES. 4.7K J 0603
(XP1000)
R344A.344B
008-06822-600-0
CHIP RES. 6K8 J 0603
(XP600)
R4.5.6.7
006-33023-420-0
MF RES.33K F 0.5W M
RA1
076-02411-001-0
RELAY T9AS1D12-24 (02182)
(XP1000)
SPK-GND
212-10010-700-0
1P WAFER/P 200MM
UL1015#14 BLK
SPK-GND
212-10010-710-0
1P WAFER/P 250MM
UL1015#14 BWN
SW1.2.3.4
210-60001-000-0
SLD/SW SLD-43-10
T1
211-10084-020-0
8P WAFER/S 396108 180
P=3.96MM
VR1.2
PHONIC CORPORATION
023-50230-040-0
D.ROT/VR 5KA 20MM P
XP 600/1000 SERVICE MANUAL
Page 25
MISCELLANEOUS ITEMS
MISCELLANEOUS ITEMS
Re f.
Phonic Part No.
Desc ription
211-17000-410-0
BINDING POST BP-47-2P
212-10010-650-0
1P WAFER/P 100MM
UL1015#14 RED
307-00000-070-0
CORD CONNECTOR C5
321-00000-020-0
CABEL TIE
140MM
321-00000-070-0
CABLE TIE
HW-100MM
347-00000-201-0
FAN JF0825S2H-419
510-20960-102-0
XP600/1000 PANEL
511-20650-101-0
BACK PANEL SECC T=1.2MM
XP600/1000
516-20430-102-0
TOP COV
524-20006-012-0
HANDLE XP600/1000
525-00009-100-0
FEET
528-00000-000-0
FAN NET
529-20026-001-0
LENS PMMA 45.6*11.6
540-20390-120-0
R/KNOB D18*18MM BLK
552-20048-420-0
ADHESIVE FIXED FW-5D-3M
552-20054-401-0
X'MER FIXED XPSERIES
560-21020-300-0
CARTON XP600
D26.5*11 BLK
WHT PWA2200 8"
614*522*205MM A=B
561-21260-500-0
G/B XP600 597*505*185MM
565-20051-020-0
LF POLYLON XP600/1000
565-20053-020-0
RT POLYLON XP600/1000
566-10015-010-0
SPONGE
568-00003-000-0
PE BAG #10 240*340*0.05
568-20018-000-0
PE BAG
630*630*0.07
572-00000-050-0
DRYER
5g
573-10124-010-0
GND LABEL MAR2
573-20340-001-0
LABEL D25 BLK
573-20402-030-0
LED LABEL LEVEL METER
40*10*5
LABEL XP/XP600/1000
573-20411-032-0
PVC PANEL LABEL
573-60240-000-0
BAR CODE LABEL PHONIC
SERIES LABEL
573-60343-000-0
LABEL LEVEL METER LABEL
BLUE D=8mm
573-60351-001-0
PHONIC CORPORATION
POWER OUT LABEL
XP 600/1000 SERVICE MANUAL
Page 26
MISCELLANEOUS ITEMS
MISCELLANEOUS ITEMS
Re f.
Phonic Part No.
Desc ription
574-34640-111-0
OWN. MANU.
579-00000-068-0
MINI CATALOG PHONIC
SERIES
590-53006-200-0
M/E SET SCR.
M3.0*6 BLK
610-00300-516-0
FIBER WAS.
610-60300-700-0
PAN SPR WAS.
D3*D8*0.5 RED
D3.0*6.0*0.7ZN
619-06380-320-0
PLA RIVET SR-3L BLK
AMP
630-20046-410-0
MYLAR INSU 268*48*0.5MM
BOT COV FIX X'MER
610-00601-000-2
PLA WAS D6*D12*1.0MM BLK
BOT COV&HEAT SINK
610-60401-001-0
PAN SPR. WAS. D4*7.6*1.0 NI
FAN&HEAT SINK
615-20035-600-0
BOSS D8*D6*7MM
FIX BACK
590-03006-200-0
M/E FLT SCR.
590-46015-200-0
M/E PANE SCR. M6.0*15 BLK
600-00605-000-0
HEX. NUT
FIX FAN BRACKET
590-53012-200-0
M/E SET SCR. M3.0*12 BLK
FIX FAN BRACKET
600-00302-210-0
HEX. NUT
FIX FAN HEAT SINK
590-44040-200-0
M/E PAN SCR.
FIX FAN NET
610-00408-001-0
PLA. WAS. D4.0*8.0*1.0 NI
FIX M'MER
610-60601-001-0
PAN SPR. WAS. D6*D12*1 NI
FIX NERTRIK*4
590-03010-200-0
M/E FLT SCR.
M3.0*10 BLK
FIX VR PCB
590-53004-100-0
M/E SET SCR.
M3.0*4 NI
FIXE PANEL&HANDLE
590-04008-100-0
M/E FLT SCR. M4.0*8 NI
FIXED FEET
591-54010-200-0
T/P SET SCR.
FIXED LED PCB
615-20108-100-0
PCB BOSS M3*13MM
FIXED POWER PCB
615-20107-100-0
PCB BOSS M3*14MM
FIXED PWR PCB&BOT
590-33008-200-0
M/E RUD SCR. M3.0*8 BLK
FIXED ROT/VR PCB
615-20110-100-0
PCB BOSS M3*5MM
GND
315-00000-000-0
LUG
GND
600-00403-510-0
HEX. NUT
M4.0*3.5 NI
GND
600-00602-010-0
HEX. NUT
M6.0*2.0 NI
GND
610-30400-501-0
TOOTH WAS.
M3.0*6 BLK
PANEL&PANEL*4
FIX BOT COV & X'MER
FIXED
FIX BOT COV&X'MER
M6.0*5.0 ZN
FIXED
M3.0*2.2 NI
M4.0*40 BLK
D4.0*10 BLK
COV.*5 LED PCB*2
D4 FOR GROUND
D4.0*D8.5*0.5
NI
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 27
MISCELLANEOUS ITEMS
MISCELLANEOUS ITEMS
Re f.
Phonic Part No.
Desc ription
GND
615-10001-130-0
EARTH BOSS
GND SCREW FIX BOT
590-44010-200-0
M/E PAN SCR M4*10 BLK
615-10002-130-0
EARTH BOSS
2+5 NI
COV HEAT SINK
GND TERMINAL
10+5 NI
(EARTH BOSS)
HEAT SINK
610-00402-018-0
FIBER WAS D4.0*D9.0*2.0
RED
HENDEL&PANEL*6
590-44008-200-0
M/E PAN SCR.
M4.0*8 BLK
PANEL&BACK PANEL*6
590-54006-200-0
M/E SET SCR.
M4*6 BLK
PHONIC JACK
610-20901-001-0
TOOTH WAS D9*12*1 NI
POWER PCB
610-30300-501-0
TOOTH WAS.
D3.0*D6.5*0.5
NI
POWER SW
212-10010-750-6
1P WAFER/P 1617#14 AWG
370MM BLUE
POWER SW
212-10010-760-6
1P WAFER/P 1617#14 AWG
320MM RED
POWER SWE
210-03101-070-0
SSA/SW
SELECTIVE VOLTAGE
618-14180-662-0
SPEC FIXED PIN SR-2 WHT
VR1.2
630-20047-410-0
MYLAR INSU 63*35*0.5MM
XLR/JACK
591-03008-200-0
T/P FLT SCR.
S34-61000-000-0
XP600/1000 MATERIAL
510-20960-102-F
XP600/1000 PANEL
511-20650-101-F
BACK PANEL
516-20430-102-F
TOP COV XP2000/3000(B)
D3.0*8 BLK
600/1000
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 28
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
Ref.
PIII600
Phonic Part No.
Description
070-20548-800-0
X'MER 115/230V PIII600
280-20263-000-0
FUSE T2A 250V VDE S
280-63263-000-0
FUSE 6.3A 250V VDE/CE S
281-00000-020-0
FUSE CLIP
BS
FUSE1.2
FH-1206 (ONLY
XP600)
370-26640-432-6
P/CORD 250V/15A 2.5M 3P BS
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0
FUSE LABEL
T6.3A
250V(ONLY XP600)
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PIII1000
BS
070-20558-800-0
X'MER 115/230V PIII1000
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
280-20263-000-0
FUSE T2A 250V VDE S
370-26640-432-6
P/CORD 250V/15A 2.5M 3P BS
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PIII600
IEC
FUSE1 FUSE2
070-20548-800-0
X'MER 115/230V
PIII600
280-20263-000-0
FUSE T2A 250V VDE S
280-63263-000-0
FUSE 6.3A 250V VDE/CE S
281-00000-020-0
FUSE CLIP
370-23610-902-0
P/CORD 230V 15A 2.5m3P
527-11000-000-0
STR.REL BUSHING 6W3-4 R
FH-1206
(6N3-4)
PIII1000
573-20079-010-0
FUSE LABEL
T6.3A 250V
070-20558-800-0
X'MER 115/230V PIII1000
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
280-20263-000-0
FUSE T2A 250V VDE S
370-23610-902-0
P/CORD 230V 15A 2.5m3P
IEC
FUSE1.2
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 29
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
Ref.
Phonic Part No.
Description
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PIII600
SA
FUSE1.2
070-20548-800-0
X'MER 115/230V
PIII600
280-20263-000-0
FUSE T2A 250V VDE S
280-63263-000-0
FUSE 6.3A 250V VDE/CE S
281-00000-020-0
FUSE CLIP
370-15020-829-0
P/CORD 15A/250V 1.0MM*3 6F
FH-1206
3P
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
PIII1000
573-20079-010-0
FUSE LABEL
T6.3A 250V
070-20558-800-0
X'MER 115/230V PIII1000
070-20558-800-0
X'MER 115/230V PIII1000
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
280-20263-000-0
FUSE T2A 250V VDE S
370-15020-829-0
P/CORD 15A/250V 1.0MM*3 6F
SA
FUSE1.2
3P
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PIII600
UL
FUSE1.2
070-20548-800-0
X'MER 115/230V
PIII600
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
280-2026B-000-0
FUSE
281-00000-010-0
FUSE CLIP
FH-1208
281-00000-020-0
FUSE CLIP
FH-1206
370-08810-702-0
P/CORD 120V20A 2.5m
2A 250V UL/CSA/JIS S
2.0MM/3PUL/CSA
527-14000-000-0
STR.REL BUSHING 6W3-4 S
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 30
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
Ref.
PIII1000
Phonic Part No.
Description
070-20558-800-0
X'MER 115/230V PIII1000
280-1538B-000-0
FUSE 15A 250V UL/CSA/JIS S
280-2026B-000-0
FUSE
370-08810-702-0
P/CORD 120V20A 2.5m
UL
FUSE1.2
2A 250V UL/CSA/JIS S
2.0MM/3PUL/CSA
PIII600
527-14000-000-0
STR.REL BUSHING 6W3-4 S
573-20334-010-0
FUSE LABEL 15A 250V(12*2.5)
070-20540-600-0
X'MER 100V JIS PIII600
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
280-2026B-000-0
FUSE
281-00000-010-0
FUSE CLIP
FH-1208
281-00000-020-0
FUSE CLIP
FH-1206
370-24610-602-0
P/CORD 100V 12A 2.5m
JIS
FUSE1.2
2A 250V UL/CSA/JIS S
1MM/2P JIS
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
PIII1000
JIS
B34-62013-220-1
070-20550-600-0
X'MER 100V JIS PIII1000
280-1538B-000-0
FUSE 15A 250V UL/CSA/JIS S
280-2026B-000-0
FUSE
370-24810-602-0
P/CORD 125V/15A 2.0MM/2P
2A 250V UL/CSA/JIS S
2.5M JIS
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20334-010-0
PIII600
SAA
FUSE1.2
FUSE LABEL 15A 250V(12*2.5)
B34-61016-510-1
070-20548-800-0
X'MER 115/230V
PIII600
280-20263-000-0
FUSE T2A 250V VDE S
280-63263-000-0
FUSE 6.3A 250V VDE/CE S
281-00000-020-0
FUSE CLIP
370-12640-631-6
P/CORD 15A/250V 3P 2.5m
FH-1206
(1.0)SAA
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 31
POWER REQUIREMENT CLASSIFICATION
POWER REQUIREMENT CLASSIFICATION
Ref.
Phonic Part No.
Description
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
573-20079-010-0
PIII1000
SAA
FUSE LABEL
T6.3A 250V
B34-62016-510-1
070-20558-800-0
X'MER 115/230V PIII1000
280-1038B-001-0
FUSE 10A 250V UL/CSA/JIS S
FUSE1.2
280-20263-000-0
FUSE T2A 250V VDE S
R281
370-12640-631-6
P/CORD 15A/250V 3P 2.5m
(1.0)SAA
R316
527-11000-000-0
STR.REL BUSHING 6W3-4 R
(6N3-4)
R241.242.243.248.249.2
50
PHONIC CORPORATION
573-60022-010-0
FUSE LABEL 10A 250V
(12*2.5)
XP 600/1000 SERVICE MANUAL
Page 32
DIMENSIONS
DIMENSIONS
347.2/13.67
374.2/14.73
442.4/17.42
89/3.5
482.6/19
Measurement are shown in mm/ inch.
PHONIC CORPORATION
XP 600/1000 SERVICE MANUAL
Page 33